Subscribe to our newsletter

TerraLOC is the modern answer to a very old problem – DUST – and is ideal for industry, construction, mining and military application.

temporary-transportation-j-l-a-terraloc-dust-abatement

Contact

Phone Jayline Australia on +61 2 4324 5266

Phone:
+61 2 4324 5266

Jayline Australia, 1/16 Jusfrute Drive, West Gosford NSW 2250, Australia

Address:
1/16 Jusfrute Drive, West Gosford,
NSW 2250 Australia

Send an email to Jayline Australia

Email:

Send a fax to Jayline Australia on +61 2 4325 0004

Fax:
+61 2 4325 0004

TerraLOC Dust Suppression Solution

TerraLOC is a user-friendly, environmentally safe, dust abatement system that WORKS

  • TerraLOC is a dust suppression product which locks soil & dust in its place.
  • TerraLOC is a non-toxic, biodegradable, and environmentally safe dust abatement product.
  • TerraLOC can be cleaned from unwanted surfaces with just water. It will not harm equipment even after it cures.
  • TerraLOC is water-reactivating. This allows particles that have settled and ruts in the bound matrix to be locked down.
  • TerraLOC reduces water needed to suppress dust. This results in eco-friendly cost savings.

TerraLOC is a solution of polyvinyl alcohol (PVOH) and additives. The solution is organic, bio-degradable, non-toxic and non-corrosive. TerraLOC has a slight amine odour, is beige in colour and penetrates the soil when used.

TerraLOC Characteristics

  • Does not require pre-wetting, though adhesion properties will benefit from pre-wetting soils.
  • Bio-degradable, unlike blanketing products.
  • Invisible after the curing process.
  • Soil penetration depths are a factor of viscosity, volume of solution and soil type.
  • Equipment can be cleaned with hot or cold water, no additional cleaners are needed.
  • Not hazardous to operators, vegetation or wildlife.
  • Curing time ranges from 3 to 20 hours and is dependent on ambient temperature, soil moisture content, soil temperature and relative humidity.
  • Dilution rates vary and require site assessment with desired result evaluation.
  • Longevity of application is determined by land use.
  • Recommended application temperature is above 21° C.
  • Recommended storage temperature range between 10°-38° C.
  • Product can be re-activated with water.
  • Increases effectiveness of daily watering schedule saving fuel, manpower, $,and the environment.
  • Captures dust which has migrated onto the treated area after the initial application.
  • Repair cracks in treated area with water only.

TerraLOC Application Rates Dust Abatement And Erosion Control

Use Rates Gallon per AcreLitre/HaSqm per liter
  Low Rate High Rate Low Rate High Rate Low Rate High Rate
Aircraft Runways  1,000  1,200  9,340  11,208  1.1  0.89
Helicopter Landing Pads  1,000  1,200  9,340  11,208  1.1  0.89
Gravel Roads  750  1,500  7,005  14,010  1.4  0.71
Heavy Haul Roads and Minin Roads  750  1,500  7,005  14,010  1.4  0.71
Military Convoy and Supply Roads  750  1,500  7,005  14,010  1.4  0.71
Landfill Capping and Reclamation  250  400  2,335 3,736  4.3  2.68
Material Stock Pile Dust Capping  250  600  2,335  5,604  4.3  1.78
Rail Car Capping  250  400  2,335  3,736  4.3  2.68
Mine Tailing  250  400  2,335  3,736  4.3  2.68
Road Shoulders  250  400  2,335  3,736  4.3  2.68
Residential Driveways  500  1,000  4.670  9,340  2.1  1.07
Erosion Control  150  300  1.401  2,802  7.1  3.57
Hydroseed and Hydromulch Tackifier  50  100  467  934  21.4  10.71
Dust Control no traffic (30 Days)  75  100  701  934  14.3  10.71
Dust Control no traffic (90 Days)  100  200  934  1,868  10.7  5.35
Dust Control no traffic (6 Months)  200  400  1.868  3,736  5.4  2.68
Golf Course Cart Paths  150  300  1.401  2,802  7.1  3.57
Walking Trails  250  400  2,335  3,736  4.3  2.68